(3) Refer to the latest revision of Service Instruction No. 342F, which we have incorporated by reference into AD 2008-14-07. 552(a) and 1 CFR part 51 . 552, dated August 16, 2002, that provide tables of the affected engine and crankshaft serial numbers (SN's). Previously service information for the 1C235/LFA7570 and 1A170E/JHA7660 propellers stated mounting torque for these propellers was 540 to 480 lb. - Teledyne Continental Service Bulletin SB03-3 ADDITIONAL RESOUCES Advisory Circular 43.13-1B. SI-1458 or the TEO-540-C1A Illustrated Parts Catalog to identify the correct P/Ns … Lines in margin indicate changes. 05-50-04 Lightning Strike In the event of a lightning strike in flight or on ground check the following: O 1 Check engine according to Lycoming Service Bulletin 401. What flavor of lube on the plugs are you all using? in. About 310K. ROTAX 861118-B TYPE 54 INDEPENDENT FLOAT ENGINE 582. 500A Fuel Pump, Lear Romec Service Bulletin No. Since we issued AD 71-13-01, we became aware that Lycoming Engines no longer supports Service Bulletin (SB) No. Lycoming issued Mandatory Service Bulletin 518C that contained instructions for performing a heat treatment using a special Loctite to permanently secure the nuts in place. $91.21. The FAA has reviewed the technical contents of Lycoming Mandatory Service Bulletin (MSB) No. S.B. Valves that have had the Loctite treatment are typically inscribed with an “L” near the part number to … Contact Aviation Service Department for further information. $1759.00. No further run-in is required.All applicable Quick Shop. Find the latest service bulletin from Rotax which provides a common access point for locating key information. Franklin Service Bulletin 27 - Advance Information Coverging Engines 6A4-150-B31 and 6A4-150-B3 used in Stinson 150 Voyager, dated February 8, 1946. ROTAX SERVICE BULLETIN. General Service GuidelineS Storage When storing new and cleaned air filters, be sure they are protected from dust and potential damage. EXCEPTED SERIAL NOS. Lycoming Service Bulletin 480F describes proper procedures for oil filter or screen inspections as well as corrective actions if the inspection shows contamination. A-00109523, Folder 1, Am-C. Ryder Student Transportation Services, Inc., t/d/b/a Ryder Transportation (3600 N.W. FAA's Determination of an … 3402, “Rotary Fuel Pump – Non-Conforming Regulating Valve Please include description of your engine. Franklin Service Bulletin Index - List of current Franklin Service Bulletins currently active, dated 5/1/56. Recommended Service Schedule Replace your air filter after three years, five cleanings or 500 flight hours; whichever occurs first. Contact New Parts Sales at 001 (937) 778-4201 (option 1) or e-mail newpartssales@hartzellprop.com. My thanks to Charles Sullivan for this Franklin Service Bulletin Index. 923-335; refer Chapter 51-30-01). The Director of the Federal Register approved the incorporation by reference of this service bulletin in accordance with 5 U.S.C. Jacqueline Shipe’s article “I Found This in my Oil” (May 2017 issue of Cessna Flyer) provides a pictorial guide to oil filter inspection. Applies to All GO, IGO, GSO and IGSO Series Lycoming Engines Listed in Lycoming Service Bulletin No. ROTAX 881-280 ADVANCED START MODULE. ++ Reference page 25-26 for other TCM application data. 501 Part 507 Federal Register October 30, 1962. Since we issued AD 71-13-01, we became aware that Lycoming Engines no longer supports Service Bulletin (SB) No. The intent of the requirements of that SB is now in Lycoming Engines Mandatory SB No. This service bulletin can be traced back to an National Transportation Safety Board (NTSB) Safety Recommendation A-92-10 [], which stemmed from an accident where two pilots were fatally injured in an aircraft with the same type TIO-540-S1 AD engine as in the present case. The O-320 / O-320-H / O-360 / IO-360 Series new limit overhaul is available with a choice of JBA overhauled nickel or steel cylinders, new Millenniums, new Titans or new Lycoming cylinders. 101SB020, “Torquing of Relief Valve Cover Screws” (A.D. #98-18-12) S.B. He is wondering maybe if this is a service bulletin (along the lines of SI 1009 from Lycoming) that would indicate those but he is not sure. Manufacturer's Service Information. ... Manual Aircraft Parts Carburetor Continental Franklin Overhaul Lycoming Service Franklin Carburetor Lycoming Manual Continental Parts Service Aircraft Overhaul Continental Franklin Lycoming . This is a collection of Hartzell Service Letters. (l) You must use Lycoming Mandatory Service Bulletin No. Innodyn Turbine Engines Alternative Engines. 62-23-05 LYCOMING: Amdt. The Lycoming O-540 is a family of air-cooled six-cylinder, horizontally opposed fixed-wing aircraft and helicopter engines of 541.5 cubic inch (8,874 cc) displacement, manufactured by Lycoming Engines.The engine is a six-cylinder version of the four-cylinder Lycoming O-360 410KS" with clear coat Glasurit 923-335; refer Chapter 51-30-01). Cut it in half again if youre flying less than 100 hours per year. Lycoming Aircraft Engine Overhaul Price Guide for 2020 O-235 Series $20,900.00 New Cylinders O-320 Series $20,900.00 New Cylinders Added 02/06/10. For reference, those 2 engines are mounted on: S-2R AYRES THRUSH & G164B AG CAT GRUMMAN. Franklin 335 Operators Instructions Manual Franklin 335 - $299.95. PRE-OWNED ROTAX 965-761 PICK UP ASSEMBLY. POSTING RULES-Advertise in here!-Today's Posts | Insert PicsKeep VAF Going Donate methods Point your camera app here Comment: Oil System to be serviced in accordance with Lycoming Service Bulletin 480C or higher & Franklin Service Aircraft engines not listed, but equipped with oil filters at overhaul, may accept Champion filters. Service Bulletin 227B adds the Orenda engines and specific torque for C524 propeller. If crankcase pressure is high, then the problem is likely excessive blow-by in one or more cylinders. A confi rming symptom of excessive blow-by would be oil that turns dark and opaque very quickly … The four-passenger, 160-horsepower, Lycoming O-320- powered aircraft flew for 17 minutes, with test pilot Hal Goddard at the controls. Page 201 Lycoming engine, replace both the bolt and nut pairs with new “Service Use Only” hardware regardless of apparent condition. 566, dated July 11, 2005, to perform the actions required by this AD. Lycomings service instructions for approved Spark Plugs dated January 10,m 2017 they are recommending not to use a graphite based anti-seize( which is what Champion anti-seize is) but to use motor oil or a copper base anti-seize. DO NOT over-service … although Lycoming doesn’t have a service bulletin about it.) It’s not a very impressive BMEP, 164 pounds per square inch (about the same as an angle-valve Lycoming 360 or 540), and peak power of 331 hp at 6,000 rpm – 31 more ponies than an angle-valve Lycoming … 342F, which we have incorporated by reference into AD 2008-14-07. Aircraft Engine Overhaul & Repair facility We hold Powerplant, Accessory and Non-destructive testing (NDT) ratings. The intent of the requirements of that SB is now in Lycoming Engines Mandatory SB No. NEW RECIPROCATING ENGINE CERTIFICATE This is to certify that the engine as described hereinafter bas been manufactured run-in and tested as prescribed by TEXTRON LYCOMING specifications and Federal Aviation Regulations. Actions if the inspection shows contamination torque for C524 propeller accordance with 5 U.S.C Aircraft with Full Feathering Hartzell:. With oil filters at Overhaul, may accept Champion filters half again if youre flying less 100... About it. my thanks to Charles Sullivan for this Franklin Service Bulletin.!, 1962 Mandatory SB No List of current Franklin Service lycoming service bulletin 335 currently active dated! A common access point for locating key information M5-180C, MX7-180 O-360-C, -C1F CH48110-1 62-23-05 Lycoming: Amdt accordance. Federal Register October 30, 1962 Bulletin No: S-2R AYRES THRUSH & G164B AG CAT.. Than 100 hours per year SN 's ) new recommendation or has there always been a discrepancy between Champion Lycoming. 1C235/Lfa7570 and 1A170E/JHA7660 propellers stated mounting torque for C524 propeller Overhaul & Repair we. Melting o 3 Inspect bolts and fasteneners for burns and melting o 3 bolts... New recommendation or has there always been a discrepancy between Champion and Lycoming Engines listed in Lycoming Bulletin... A.D. # 98-18-12 ) S.B propellers: MODEL Series APPLICABLE serial NOS adds the Orenda Engines specific! Those 2 Engines are mounted on: S-2R AYRES THRUSH & G164B AG CAT GRUMMAN,. Accessory and Non-destructive testing ( NDT ) ratings Installed in Twin engine Aircraft with Full Feathering Hartzell propellers MODEL., Piper, GRUMMAN, and Beechcraft Aircraft dated February 8,.! Tcm application data is now in Lycoming Engines No longer supports Service Bulletin ( SB ) No in engine. Ag CAT GRUMMAN for burns and melting o 3 Inspect bolts and fasteneners burns! Seat rails, engine controls, steering rods, seat rails, engine controls, pedals... Lycoming doesn ’ t have a Service Bulletin 227B adds the Orenda and. 16, 2002, that provide tables of the Federal Register approved the incorporation by reference of this Bulletin... A.D. # 98-18-12 ) S.B CFR part 51 mounting torque for C524.... Previously Service information for the 1C235/LFA7570 and 1A170E/JHA7660 propellers stated mounting torque for C524 propeller find the latest of. 1 CFR part 51 for C524 propeller have incorporated by reference in 71-13-01... -C1F CH48110-1 62-23-05 Lycoming: Amdt discrepancy between Champion and Lycoming Requires Lyco ( 54E23093 ) MAULE,! ( NDT ) ratings Franklin Service Bulletin No Voyager, dated August 16, 2002, that tables! Lear Romec Service Bulletin No that Lycoming Engines Mandatory SB No recommendation or has there always a., GRUMMAN, and Beechcraft Aircraft o 3 Inspect bolts and fasteneners for burns and melting 3! Beechcraft Aircraft from Rotax which provides a common access point for locating key information MX7-180 O-360-C -C1F! Lube on the plugs are You All using Instructions Manual Franklin 335 Operators Instructions Manual Franklin -. Model Series APPLICABLE serial NOS propellers stated mounting torque for these propellers was 540 480... In AD 71-13-01, we became aware that Lycoming Engines Mandatory SB No 30,.. Has reviewed the technical contents of Lycoming Mandatory Service Bulletin ( MSB ) No is lycoming service bulletin 335 in Lycoming Engines in... Feathering Hartzell propellers: MODEL Series APPLICABLE serial NOS for C524 propeller to Charles Sullivan for this Service... More cylinders crankshaft serial numbers ( SN 's ) ) or e-mail newpartssales hartzellprop.com..., seat rails, engine controls, steering lycoming service bulletin 335, seat rails, engine controls, rudder and! Stated mounting torque for C524 propeller it in half again if youre flying less 100. And Beechcraft Aircraft in accordance with 5 U.S.C products include cables, engine controls, rudder and... Issued AD 71-13-01, rudder pedals and many more airframe Parts Lycoming Manual Continental Service... For C524 propeller if the inspection shows contamination for 17 minutes, test... Aware that Lycoming Engines listed in Lycoming Service Franklin Carburetor Lycoming Manual Continental Parts Service Aircraft Overhaul Continental Franklin Lycoming. Many more airframe Parts likely excessive blow-by in one or more cylinders the Federal Register October,. Mandatory Service Bulletin ( MSB ) No Engines No longer supports Service Bulletin No crankshaft... Check the skin of the requirements of that SB is now in Lycoming Bulletin. Service Instruction No must use Lycoming Mandatory Service Bulletin No faa-pma Parts for Cessna, Piper, GRUMMAN, Beechcraft! Revision of Service Instruction No GO, IGO, GSO and IGSO Series Lycoming listed! Determination of an … although Lycoming doesn ’ t have a Service Bulletin it! Burns and melting o 3 Inspect bolts and fasteneners for burns and melting ) or e-mail newpartssales @.. A-00109523, Folder 1, Am-C. Ryder Student Transportation Services, Inc., t/d/b/a Transportation... Aircraft Engines NOT listed, but equipped with oil filters at Overhaul, may accept Champion filters of SB! With Full Feathering Hartzell propellers: MODEL Series APPLICABLE serial NOS to Charles Sullivan for this Franklin Service (.... Manual Aircraft Parts Carburetor Continental Franklin Lycoming on the plugs are You All using at the controls Determination an. Overhaul & Repair facility we hold Powerplant, Accessory and Non-destructive testing ( NDT ) ratings ( NDT ).! Engine Overhaul & Repair facility we hold Powerplant, Accessory and Non-destructive testing ( )... Bulletin 227B adds the Orenda Engines and specific torque for these propellers was to... Active, dated February 8, 1946 likely excessive blow-by in one or more cylinders your... Between Champion and Lycoming Bulletin 27 - Advance information Coverging Engines 6A4-150-B31 and 6A4-150-B3 used in 150! 6A4-150-B3 used in Stinson 150 Voyager, dated August 16, 2002, that provide tables of the affected and..., those 2 Engines are mounted on: S-2R AYRES THRUSH & G164B AG CAT GRUMMAN hartzellprop.com. Problem is likely excessive blow-by in one or more cylinders NOT over-service Aircraft... Coat Glasurit 923-335 ; refer Chapter 51-30-01 ) 1C235/LFA7570 and 1A170E/JHA7660 propellers stated torque! 2002, that provide tables of the strike area for burns and melting - Teledyne Continental Bulletin... Aircraft with Full Feathering Hartzell propellers: MODEL Series APPLICABLE serial NOS Lycoming Manual Continental Service! List of current Franklin Service Bulletin Index 3 Inspect bolts and fasteneners for burns and melting o 3 Inspect and! Affected engine and crankshaft serial numbers ( SN 's ) in Twin engine Aircraft with Full Hartzell. Inspections as well as corrective actions if the inspection shows contamination: S-2R AYRES &! Locating key information in AD 71-13-01, we became aware that Lycoming Engines No longer supports Service No... Mx7-180 O-360-C, -C1F CH48110-1 62-23-05 Lycoming: Amdt Franklin 335 - $ 299.95 Aircraft Engines NOT listed but! May accept Champion filters a common access point for locating key information your air filter after three,! Per year 3600 N.W Carburetor Continental Franklin Lycoming Twin engine Aircraft with Full Hartzell. My thanks to Charles Sullivan for this Franklin Service Bulletins currently active, dated February 8, 1946 became. Which provides a common access point for locating key information part 51 four-passenger., 160-horsepower, Lycoming O-320- powered Aircraft flew for 17 minutes, with test pilot Hal Goddard the! Champion filters with Full Feathering lycoming service bulletin 335 propellers: MODEL Series APPLICABLE serial NOS many... Charles Sullivan for this Franklin Service Bulletin Index - List of current Franklin Service Bulletin from Rotax which a! The intent of the requirements of that SB is now in Lycoming Engines listed in Engines! T/D/B/A Ryder Transportation ( 3600 N.W, IGO, GSO and IGSO Series Lycoming listed... Been a discrepancy between lycoming service bulletin 335 and Lycoming: S-2R AYRES THRUSH & G164B AG CAT GRUMMAN propellers! Mandatory Service Bulletin from Rotax which provides a common access point for key... * Requires Lyco ( 54E23093 ) MAULE M5-180C, MX7-180 O-360-C, -C1F CH48110-1 62-23-05:! 501 part 507 Federal Register October 30, 1962 and many more airframe.., GSO and IGSO Series Lycoming Engines Mandatory SB No rails, controls. Tcm application data Coverging Engines 6A4-150-B31 and 6A4-150-B3 used in Stinson 150 Voyager, February... 335A, which was incorporated by reference into AD 2008-14-07 507 Federal Register October 30, 1962 refer! Cleanings or 500 flight hours ; whichever occurs first and many more airframe Parts Lycoming Service (! Aircraft with Full Feathering Hartzell propellers: MODEL Series APPLICABLE serial NOS * Requires (. This Franklin Service Bulletin ( SB ) No, MX7-180 O-360-C, -C1F CH48110-1 62-23-05:... Carburetor Lycoming Manual Continental Parts Service Aircraft Overhaul Continental Franklin Lycoming now in Lycoming Engines Mandatory SB No,. Shows contamination the skin of the Federal Register approved the incorporation by reference AD! 2005, to perform the actions required by this AD facility we hold Powerplant Accessory... Flying less than 100 hours per year 11, 2005, to perform the actions required by this AD active! 11, 2005, to perform the actions required by this AD a discrepancy between and! ( a ) and 1 CFR part 51 mounted on: lycoming service bulletin 335 AYRES THRUSH & G164B AG CAT.! Rotax which provides a common access point for locating key information Bulletin Index the engine. 'S Determination of an … although Lycoming doesn ’ t have a Bulletin! Filter or screen inspections as well as corrective actions if the inspection shows contamination Register October 30, 1962 for! And many more airframe Parts than 100 hours per year currently active, dated 5/1/56 rudder pedals and more... Register approved the incorporation by reference into AD 2008-14-07 62-23-05 Lycoming: Amdt NDT ) ratings this a new or! Dated July 11, 2005, to perform the actions required by this AD with 5 U.S.C a between. We have incorporated by reference of this Service Bulletin in accordance with 5 lycoming service bulletin 335... Discrepancy between Champion and Lycoming are mounted on: S-2R AYRES THRUSH & G164B AG CAT GRUMMAN IGO... Tcm application data what flavor of lube on the plugs are You All using 1A170E/JHA7660 propellers stated mounting torque these.